2022 Kia EV6 RWD
Standard Range
Electric SUV · RWD
Based on battery health, build quality, owner data, EPA range, and market pricing
Below average for 2022 EV SUVs (class avg 66)
Personalize this scoreIs a low score bad?
Last scanned 12 days ago
The 2022 Kia EV6 RWD (Standard Range) packs 167 hp, 232 miles of EPA range and a 55 kWh battery, and the score gets it into the conversation; battery and service records decide whether to make an offer.
Score read
A 65/100 makes this a paperwork-and-test-drive decision. Build quality score is the cleaner read at 71/100; range and efficiency score needs more diligence at 55/100. Owners on Reddit repeatedly cite software tech and owner satisfaction as recurring problems. A clean VIN lookup matters more than the headline count.
Is it a good deal?
Used examples are running around $20,987 against a $40,900 original sticker, about 51% of new. A reasonable spot for the score, but condition matters more than the headline number; verify recall completion, battery health, and service history.
Who this is for
✓ Good for
- ⏱ Daily commuter ≤50 mi/day, predictable charging
✗ Avoid if you are a
No persona-level disqualifiers — fits broadly.
Gotchas
- Serviceable Recall paperwork has to match the exact VIN.
Mitigation Use NHTSA and the automaker lookup, then require repair records instead of a verbal promise.
- Built in Range is the easy place to overbuy this trim (55/100).
Mitigation Check your commute, winter margin, and fast-charge plan before you assume the EPA number fits your use.
Pre-purchase inspection
- 1 Run the exact VIN through NHTSA and the automaker recall lookup before discussing price.
- 2 Compare the dashboard range estimate with the EPA 232-mile rating after a full charge.
- 3 Confirm how much of the 10-year/100,000-mile battery warranty remains and whether it transfers.
- 4 If road trips matter, run a short DC fast-charge session and watch whether speed tapers normally.
- 5 Map your normal highway route and winter margin against the EPA range before you treat it as a road-trip car.
VIN status first This model has 3 NHTSA recall records. The exact VIN lookup decides whether the car in front of you is clear.
Complaint context This scan found 259 NHTSA complaint records (47.1 per 10K VINs, high — material safety/build concern). Read the themes below before treating the raw count as the verdict.
Price anchor Current market range is $17,350-$20,987. Use that range to compare listings for the same trim, mileage, and condition.
Pricing & Market Value
A65-rated trim trading 53% below MSRP. Higher discounts on higher-quality vehicles score better — this signal is orthogonal to the TrimIndex composite, not part of it.
Score Breakdown
What matters most to you?
Drag the sliders to prioritize what you care about. Your TrimIndex Score recalculates instantly.
Vehicle Specifications
EVs at your price point that match or beat this trim
Price-gated peer set: vehicles within $15.3K–$23.0K market value (±20% of $19.2K). 4 outscore · 2 score within ±2. Mixed across makes — no "spend more, score better" comps.
Bolt EUV
- ✓ Better infotainment UX
- ✓ Happier owners overall
- ✓ Notably better build quality
EV6
- ✓ +78 mi more range
- ✓ Better infotainment UX
- ✓ Better safety score
Ioniq 5
- ✓ Better infotainment UX
- ✓ +71 mi more range
- ✓ Better safety score
Kona
- ✓ Better infotainment UX
ID.4
- ✓ Better infotainment UX
- ✓ Better bang-for-buck
- ✓ Happier owners overall
Niro
- ✓ Better infotainment UX
The federal $4,000 used-EV credit ended Sept 30, 2025.
But 10 states still run their own used-EV rebate programs — some up to $5,000. Pick your state to see what's available for this trim.
Source & disclaimer
Dealers make ~$7,065 on the average car loan.
After the price is set, the finance manager runs four plays to rebuild margin. Every buyer without a pre-approval is a target. Here's exactly what they run — and what stops each one.
78% of dealer loans carry a hidden +1.13% markup above what the lender actually charges. You never see it — it's buried in the contract. · CFPB
Dealer must match or beat your lender — they can't add margin invisibly. The markup play is dead on arrival.
Once you answer, they stretch the term to hit your number. Median result: $4K less off the price, 12 more months on the loan. · Industry avg
Financing is done. Only the sale price is on the table — and the dealer knows it.
Back-office F&I profit averages $1,975/vehicle, up 8.5% YoY. These products exist — but dealer markup is 4–10x what you'd pay elsewhere. · Dealership Guy
Dealer GAP runs $500–1K. Your insurer sells the same coverage for $100–250 over 5 years. Now you know.
"Your loan fell through — come re-sign." This pulls your APR up +5% on average. It's legal. It works because you've already driven the car home. · Ctr for Responsible Lending
A lender commitment letter means the deal is final. "Pending dealer approval" doesn't apply. You can't be yo-yo'd.
That's 25 months of your car payment — handed to the dealer's finance department for nothing.
Takes 2 minutes. No obligation to use it — but you'll walk in with all the leverage.
Pre-approval is a soft credit inquiry — no score impact. FICO treats all auto-loan hard pulls within 14 days as one, so you can still shop rates at the dealer.
NHTSA Recalls (3)
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
A loss of drive power increases the risk of a crash.
Check VIN status at NHTSA.govKia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
A loss of drive power increases the risk of a crash.
Check VIN status at NHTSA.govKia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Vehicle rollaway can increase the risk of a crash or injury.
Check VIN status at NHTSA.govNHTSA Complaints (259 total · 47.1 per 10K US vehicles · high — material safety/build concern)
Sunroof glass spontaneously exploded outwards while driving on the highway with a loud boom
Sunroof glass spontaneously exploded outwards while driving on the highway with a loud boom
On [XXX], I pulled into a parking space, and the car suddenly accelerated, jumped the curb, and hit the building. This is the second time this happened. It happened when I was parking in May 2022; the car suddenly accelerated and struck a fence. In all my time driving this car, I have never had an issue breaking or parking. There was an immediate surge in both cases, and I am confident that my foot was on the break. In both cases, I did not get any collision warning from the car or emergency braking. I know from experience driving this car that when the vehicle /system determined I was too close to something of danger, I would get a collision warning and an immediate breaking by the vehicle. I reported the issue to the KIA dealership for the first time and wrote a report; they said they had not heard of the problem but would note it. If there had been a person walking when this happened, I am sure serious, if not fatal injuries would be occur. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On [XXX], I pulled into a parking space, and the car suddenly accelerated, jumped the curb, and hit the building. This is the second time this happened. It happened when I was parking in May 2022; the car suddenly accelerated and struck a fence. In all my time driving this car, I have never had an issue breaking or parking. There was an immediate surge in both cases, and I am confident that my foot was on the break. In both cases, I did not get any collision warning from the car or emergency braking. I know from experience driving this car that when the vehicle /system determined I was too close to something of danger, I would get a collision warning and an immediate breaking by the vehicle. I reported the issue to the KIA dealership for the first time and wrote a report; they said they had not heard of the problem but would note it. If there had been a person walking when this happened, I am sure serious, if not fatal injuries would be occur. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
ICCU failure. It blew up my home charger and shorted out. Would no longer charge the car on level 1 or 2 charger.
ICCU failure. It blew up my home charger and shorted out. Would no longer charge the car on level 1 or 2 charger.
ICCU failed needed replacement, 2 weeks after 12v battery died.
ICCU failed needed replacement, 2 weeks after 12v battery died.
Most vehicles with ABS experience what I call “ABS shudder/jutter” when applying brakes across a road seam where the road surface is uneven or a rut in the road. In this particular case while applying the brakes across a long rut in the road, the “ABS shudder/jutter” was much worse. NOT SPEEDING and having plenty of distance to stop. With brake pedal to the floor several times, the vehicle continued to move forward. The last few feet before colliding with a pickup truck, although the road was completely dry, the vehicle was driving forward yet sliding forward slowly. Felt no different than being on ice. Collision aversion system did nothing to help avoid. There is also only electronic parking brake and not an emergency brake to pull a handle on to assist in stopping. Dealership wasn’t able to find anything simply by driving around and slamming on the brakes and not finding any error codes. Regional technician currently scheduled to be here the 27th of Jan. Several people online have expressed similar concerns, just haven’t hit anything. I feel that the issue lies with the ABS system specifically braking over uneven road seams or ruts in the road and my experience is being discounted.
Most vehicles with ABS experience what I call “ABS shudder/jutter” when applying brakes across a road seam where the road surface is uneven or a rut in the road. In this particular case while applying the brakes across a long rut in the road, the “ABS shudder/jutter” was much worse. NOT SPEEDING and having plenty of distance to stop. With brake pedal to the floor several times, the vehicle continued to move forward. The last few feet before colliding with a pickup truck, although the road was completely dry, the vehicle was driving forward yet sliding forward slowly. Felt no different than being on ice. Collision aversion system did nothing to help avoid. There is also only electronic parking brake and not an emergency brake to pull a handle on to assist in stopping. Dealership wasn’t able to find anything simply by driving around and slamming on the brakes and not finding any error codes. Regional technician currently scheduled to be here the 27th of Jan. Several people online have expressed similar concerns, just haven’t hit anything. I feel that the issue lies with the ABS system specifically braking over uneven road seams or ruts in the road and my experience is being discounted.
The air bag (SRS) floor wire harness running directly under the moving front driver and passenger seats are assembled with no shielding or protection. So they are subject to being severed or damaged, and the wires are at risk of corrosion if exposed to moisture or road salt. This is clearly a preventable safety issue. However, Kia and Hyundai are not providing warranty coverage. And replacement of a damaged harness is ~$9,300+ because the harness apparently routs behind the dashboard and to the engine compartment.
The air bag (SRS) floor wire harness running directly under the moving front driver and passenger seats are assembled with no shielding or protection. So they are subject to being severed or damaged, and the wires are at risk of corrosion if exposed to moisture or road salt. This is clearly a preventable safety issue. However, Kia and Hyundai are not providing warranty coverage. And replacement of a damaged harness is ~$9,300+ because the harness apparently routs behind the dashboard and to the engine compartment.
Prior to midnight on 9/25/2025 I stopped at a Sheetz in Stephen"s City, Va to charge my 2022 Kia EV6. Upon pulling into the charging area I discovered construction fencing around the area with the chargers removed. I then drove to the other side of the store and parked next to the building to take advantage of the lighting as I scanned my phone app for alternative chargers in the area. SUDDENLY, within the blink of an eye, my car lunged forward at MAXIMUM speed. It came to a sudden stop, prior to hitting the glass and brick wall of the building. I was stunned. My first reaction was to try to go into reverse to back away from the building and then I noticed people coming toward me. I rolled the window down and heard them ask if I was ok, if I needed help calling 911, and then they began to insist that I climb down out of the car as they feared it would catch on fire. I did not understand what they meant initially, until I realized I was LOOKING DOWN at them. With assistance, I got out of my car and realized it was impaled upon the metal barrier post located in the middle, front of the parking space. The local sheriff dept responded and after putting me through all the DUI tests/exercises realized that I, indeed, was sober and not responsible for the incident. The deputy called Clem's Garage/Towing who arrived 30-45 min latter with a standard tow truck - I tried to explain that tugging at my car from the rear would not release it from the pole ( the rear of the car pointed toward the pavement while the front pointed toward the sky) and that continuing to tug would only do more damage (I wanted to prevent my car further damage). He eventually called another company who arrived with a large crane-like vehicle that lifted my car off the pole. The top portion of the pole was missing and apparently stuck in my car. My car was then towed to Clem's holding yard.
Prior to midnight on 9/25/2025 I stopped at a Sheetz in Stephen"s City, Va to charge my 2022 Kia EV6. Upon pulling into the charging area I discovered construction fencing around the area with the chargers removed. I then drove to the other side of the store and parked next to the building to take advantage of the lighting as I scanned my phone app for alternative chargers in the area. SUDDENLY, within the blink of an eye, my car lunged forward at MAXIMUM speed. It came to a sudden stop, prior to hitting the glass and brick wall of the building. I was stunned. My first reaction was to try to go into reverse to back away from the building and then I noticed people coming toward me. I rolled the window down and heard them ask if I was ok, if I needed help calling 911, and then they began to insist that I climb down out of the car as they feared it would catch on fire. I did not understand what they meant initially, until I realized I was LOOKING DOWN at them. With assistance, I got out of my car and realized it was impaled upon the metal barrier post located in the middle, front of the parking space. The local sheriff dept responded and after putting me through all the DUI tests/exercises realized that I, indeed, was sober and not responsible for the incident. The deputy called Clem's Garage/Towing who arrived 30-45 min latter with a standard tow truck - I tried to explain that tugging at my car from the rear would not release it from the pole ( the rear of the car pointed toward the pavement while the front pointed toward the sky) and that continuing to tug would only do more damage (I wanted to prevent my car further damage). He eventually called another company who arrived with a large crane-like vehicle that lifted my car off the pole. The top portion of the pole was missing and apparently stuck in my car. My car was then towed to Clem's holding yard.
The ICCU failed, causing the battery to die which left me unable to drive the car further. The car needed to be towed to the Kia dealership, who confirmed that the ICCU had failed. A warning saying check electrical system showed on the dash when the part failed
The ICCU failed, causing the battery to die which left me unable to drive the car further. The car needed to be towed to the Kia dealership, who confirmed that the ICCU had failed. A warning saying check electrical system showed on the dash when the part failed
I recently experienced a serious safety issue with my less than 3-year-old Kia EV6. The 12-volt battery unexpectedly failed, rendering the vehicle inoperable, including the doors. This occurred twice: once while the battery was still under warranty, and again after the warranty expired. The second failure left my wife and daughter stranded in a dark parking lot at night. Despite numerous online reports of similar incidents, Kia refused to replace the battery under warranty, citing the mileage. This is a significant safety concern, as a failed battery can leave drivers stranded in dangerous situations. I contacted Kia corporate to request compensation for the replacement battery, but they declined. I believe Kia should take responsibility for this widespread issue and replace these defective batteries at no cost to consumers.
I recently experienced a serious safety issue with my less than 3-year-old Kia EV6. The 12-volt battery unexpectedly failed, rendering the vehicle inoperable, including the doors. This occurred twice: once while the battery was still under warranty, and again after the warranty expired. The second failure left my wife and daughter stranded in a dark parking lot at night. Despite numerous online reports of similar incidents, Kia refused to replace the battery under warranty, citing the mileage. This is a significant safety concern, as a failed battery can leave drivers stranded in dangerous situations. I contacted Kia corporate to request compensation for the replacement battery, but they declined. I believe Kia should take responsibility for this widespread issue and replace these defective batteries at no cost to consumers.
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
The brake light does not activate in a way that would signal to other drivers that the vehicle is stopping or slowing down, while using higher regenerative braking. The ipedal mode can have a significant amount of deceleration and not activate the brake light, even coming to a full stop and not activating the light, if the driver's foot is not completely off the pedal. I have been told by other drivers that my brake lights were out when I expected that they were working. Testing this with a odb2 device and another driver following behind me confirmed that the Kia EV6 does not activate brake lights when it should. Additionally, there is a video on youtube titled "Electric cars prove we need to rethink brake lights", demonstrating this on a similar vehicle, the Hyundai Ioniq 5. https://www.youtube.com/watch?v=U0YW7x9U5TQ There is no indication in the vehicle that the brake lights are not functioning as a driver would expect. The lights do work when using the brake pedal and are not normally "malfunctioning". The nearest dealer has confirmed that the driver needs to take their foot off of the accelerator to actuate the brake lights. In my opinion, the vehicle should be recalled to apply a fix that signals braking and intent to slow down that is consistent with the deceleration of the vehicle.
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.
Brake lights do not illuminate when using the Regenerative Braking System in the Kia EV6. The vehicle is fitted with a 'one-pedal-driving' system that allows the vehicle to slow down and stop without actuation of the brake pedal. When using this system, the vehicle can decelerate rapidly and to a complete stop, however the brake lights do not illuminate unless the drivers foot is completely removed from the accelerator pedal. Doing this causes rapid deceleration beyond what would be considered normal for a driver approaching a turn or any other scenario where a planned stop will occur. Because the vehicle does not illuminate the brake lights during normal deceleration when using the one-pedal-driving feature of the regenerative braking system this significantly increases the risk of a rear end collision. The vehicle has been found to be operating normally and matches the behavior of other EV6 models. Although I have not yet been involved in a collision, I have been advised by other drivers that my brake lights are not working, and have had multiple 'close-calls' where drivers behind me have been unable to correctly determine that my vehicle is decelerating and have subsequently caused them to brake erratically or harshly putting myself and others at risk.
The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings
The vehicle does not trigger brake lights when it is using Regen braking or the ipadel mode. This can cause a safety hazard for the person behind me to crash into me without the brake lights warnings
The contact owns a 2022 Kia EV6. The contact stated that on various occasions while coming to a stop at a stop signal, a loud crunching sound was heard underneath the vehicle. The brake pedal was depressed, and the vehicle jerked forward. No warning lights were illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure reoccurred and caused the vehicle to lunge forward into oncoming traffic, causing another vehicle to almost crash into the driver's side. The vehicle was then taken back to the dealer and remained in dealer possession awaiting a further diagnostic test and repair. The manufacturer was not made aware of the failure. The failure mileage was 2,215.
The contact owns a 2022 Kia EV6. The contact stated that on various occasions while coming to a stop at a stop signal, a loud crunching sound was heard underneath the vehicle. The brake pedal was depressed, and the vehicle jerked forward. No warning lights were illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure reoccurred and caused the vehicle to lunge forward into oncoming traffic, causing another vehicle to almost crash into the driver's side. The vehicle was then taken back to the dealer and remained in dealer possession awaiting a further diagnostic test and repair. The manufacturer was not made aware of the failure. The failure mileage was 2,215.
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
The contact owns a 2022 Kia EV6. The contact stated while stopped for a traffic signal, and with her foot on the brake pedal, the vehicle lunged forward while the traffic signal was still "red." The contact stated she did not notice any warning lights or chimes. The contact stated she crashed into the rear of the vehicle in front. The contact stated that her front grill, lights, and bumper were all damaged. The contact stated that the radiator was damaged and coolant had pooled under her vehicle. The contact stated that the rear end lift gate and rear bumper of the other vehicle had sustained heavy denting and crush damage. None of the drivers were injured, only the contact's vehicle was towed due to the damaged radiator. The contact stated that she went to a chiropractor's office a day after the accident for neck pain, headache, and upper back pain. The police were on the scene and filed a report. The contact had the vehicle towed to a dealer where it was still being diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 3,000. The contact stated that the manufacturer was unable to provide them with recordings from the EDR and that the drive records from that day has zero drives on it. The company claims that the telematics show that it was a driver error but have not provided proof of that.
Car audio Amp is a huge problem in the meridian sound system because when it fails all the warning auditable system and chimes are no longer heard. This is unacceptable as you know longer can relay in the safety systems that are in place. They can not make them either as they have no suppliers. No loan a cars either.
Car audio Amp is a huge problem in the meridian sound system because when it fails all the warning auditable system and chimes are no longer heard. This is unacceptable as you know longer can relay in the safety systems that are in place. They can not make them either as they have no suppliers. No loan a cars either.
While driving with the hatch open, while carrying objects to long to place in car, (The drive was less than one mile and yes I had a red flag on my kayaks) I was driving in what is called 1Pedal driving. When coming to a stop light unbeknownst to me the emergency brakes (Parking brake) automatically comes on. I was unable to continue in drive until manually unlocking parking brake, but it took me a minute to figure out what was the issue. During this time I was blocking traffic till I figured the work around. This undoubtedly a software glitch by kia's programmers. To make sure that this was not a singular incident, I took the car on a quiet street to replicate this by keeping the hatch slightly ajar while coming to a standard stop like a stop sign as if I had stopped in traffic as well as stopping as if I was in traffic.. I attempted this over a dozen times. Each time in the 1Pedal mode the emergency brakes came on and wouldn't disengage till manually doing so. I have not tried to replicate this other regenerative braking modes other than 1Pedal. But when I get back to an area where traffic is not an issue I will see if it is an issue with those modes as well. I notified the service department of this matter when I Brought in the car in for software update for a safety recall. The service department did not do anything to see if there was a fix other than take a written statement that I left with them. This becomes a safety issue for the following reasons. 1. First, there is no mentioned in the Kia EV6 bible on this issue and this will take place, so there is no warning to the driver that this going to happen. 2. When coming to a stop and car does not move a nervous or inexperience driver may panic or not no what to do to remedy the situation, thinking the car is dead. And thus leaving a car obstructing the flow of regular as well emergency vehicular. 3. Driver behind the stalled vehicle may plow into the rear end of the stalled vehicle.
While driving with the hatch open, while carrying objects to long to place in car, (The drive was less than one mile and yes I had a red flag on my kayaks) I was driving in what is called 1Pedal driving. When coming to a stop light unbeknownst to me the emergency brakes (Parking brake) automatically comes on. I was unable to continue in drive until manually unlocking parking brake, but it took me a minute to figure out what was the issue. During this time I was blocking traffic till I figured the work around. This undoubtedly a software glitch by kia's programmers. To make sure that this was not a singular incident, I took the car on a quiet street to replicate this by keeping the hatch slightly ajar while coming to a standard stop like a stop sign as if I had stopped in traffic as well as stopping as if I was in traffic.. I attempted this over a dozen times. Each time in the 1Pedal mode the emergency brakes came on and wouldn't disengage till manually doing so. I have not tried to replicate this other regenerative braking modes other than 1Pedal. But when I get back to an area where traffic is not an issue I will see if it is an issue with those modes as well. I notified the service department of this matter when I Brought in the car in for software update for a safety recall. The service department did not do anything to see if there was a fix other than take a written statement that I left with them. This becomes a safety issue for the following reasons. 1. First, there is no mentioned in the Kia EV6 bible on this issue and this will take place, so there is no warning to the driver that this going to happen. 2. When coming to a stop and car does not move a nervous or inexperience driver may panic or not no what to do to remedy the situation, thinking the car is dead. And thus leaving a car obstructing the flow of regular as well emergency vehicular. 3. Driver behind the stalled vehicle may plow into the rear end of the stalled vehicle.
When coming to a stop while ascending a hill, the vehicle will roll backward while the brake pedal is depressed. There was enough braking force to stop the car (and prevent further forward motion), but the vehicle will roll backward.
When coming to a stop while ascending a hill, the vehicle will roll backward while the brake pedal is depressed. There was enough braking force to stop the car (and prevent further forward motion), but the vehicle will roll backward.
The Integrated Charging Control Unit (ICCU) failed twice within four weeks. The first failure occurred in March 2026 and was repaired under recall SC327 with a replacement ICCU and fuse. The second failure occurred April 7, 2026, approximately 12 days after pickup. Symptoms: Vehicle failed to charge overnight on Level 1 and Level 2 circuits despite being plugged in. Later that day, while driving, a “Check Electrical System” warning appeared on the dashboard followed by sudden loss of power and acceleration. Vehicle fluctuated between 25-45 mph and could not maintain speed. Vehicle was driven approximately 2.2 miles to the dealership under its own power after warning onset. Safety risk: Sudden loss of power and acceleration while driving created a hazardous condition for myself. Dealer confirmation: The authorized Kia dealer confirmed a DTC for battery overheating and acknowledged the ICCU coolant was not fully topped off after the first replacement, suggesting the recall remedy was incompletely performed. The vehicle has remained at the dealer unrepaired since April 10, 2026. Component available for inspection: Yes, vehicle is currently at the dealership. Recall remedy concern: The SC327 recall remedy did not resolve the ICCU failure. A second failure occurred within two weeks of the repair. The dealer’s subsequent diagnosis of owner-caused undercarriage battery damage is contradicted by their own signed inspection report documenting all undercarriage items as passed with no damage noted
The Integrated Charging Control Unit (ICCU) failed twice within four weeks. The first failure occurred in March 2026 and was repaired under recall SC327 with a replacement ICCU and fuse. The second failure occurred April 7, 2026, approximately 12 days after pickup. Symptoms: Vehicle failed to charge overnight on Level 1 and Level 2 circuits despite being plugged in. Later that day, while driving, a “Check Electrical System” warning appeared on the dashboard followed by sudden loss of power and acceleration. Vehicle fluctuated between 25-45 mph and could not maintain speed. Vehicle was driven approximately 2.2 miles to the dealership under its own power after warning onset. Safety risk: Sudden loss of power and acceleration while driving created a hazardous condition for myself. Dealer confirmation: The authorized Kia dealer confirmed a DTC for battery overheating and acknowledged the ICCU coolant was not fully topped off after the first replacement, suggesting the recall remedy was incompletely performed. The vehicle has remained at the dealer unrepaired since April 10, 2026. Component available for inspection: Yes, vehicle is currently at the dealership. Recall remedy concern: The SC327 recall remedy did not resolve the ICCU failure. A second failure occurred within two weeks of the repair. The dealer’s subsequent diagnosis of owner-caused undercarriage battery damage is contradicted by their own signed inspection report documenting all undercarriage items as passed with no damage noted
ICCU failed after 49,059 miles. Levels 1&2 charging do not work. I must use DCFC to charge the car.
ICCU failed after 49,059 miles. Levels 1&2 charging do not work. I must use DCFC to charge the car.
This make/model has a known ICCU issue. Ours went out just after warranty expired and the cost is $4,000. The EU and some Asian countries have extended the warranty of this fault due to how prevalent it is.
This make/model has a known ICCU issue. Ours went out just after warranty expired and the cost is $4,000. The EU and some Asian countries have extended the warranty of this fault due to how prevalent it is.
ICCU failure at 16k miles. The ICCU was replaced at the dealership on January, 29th of this year, so it is not available for inspection. The failure tripped a breaker at my home while it was charging possibly indicating a short circuit. The short circuit could have potentioally overheated and caught fire in my home. I took the vehicle to the dealership and they confirmed it was the ICCU and replaced it under warranty. I have a copy of the invoice received after the replacement was installed. I do not know what they did with the old ICCU after it was placed. There was no indication of pending failure that I noticed prior to this incident occuring.
ICCU failure at 16k miles. The ICCU was replaced at the dealership on January, 29th of this year, so it is not available for inspection. The failure tripped a breaker at my home while it was charging possibly indicating a short circuit. The short circuit could have potentioally overheated and caught fire in my home. I took the vehicle to the dealership and they confirmed it was the ICCU and replaced it under warranty. I have a copy of the invoice received after the replacement was installed. I do not know what they did with the old ICCU after it was placed. There was no indication of pending failure that I noticed prior to this incident occuring.
Electrical propulsion failure resulting in 3 tow-ins. Vehicle goes into limp mode, slows to 20 mph on highway and then stops after about 2 miles. The issue appears related to the ICCU, fuse and 12V battery failures. History includes 6 attached ICCU related Repairs. #1 ICCU updated under recall SC271 at 31,678 miles. #2 Then the ICCU was replaced under recall SC302 at 45,059 miles. #3 Then the ICCU was replaced along with fuse and 12V battery after on road failure and tow in at 52,296 miles. #4 Then the ICCU was updated under recall SC327. #5 Then the ICCU, fuse and 12V battery was replaced at 69,849 miles under recall SC327 after another on road failure and tow in. #6 Then there was a ICCU overheat and charging fault related to a bad ICCU coolant reservoir cap after a charging failure and tow in at 70,957 miles.
Electrical propulsion failure resulting in 3 tow-ins. Vehicle goes into limp mode, slows to 20 mph on highway and then stops after about 2 miles. The issue appears related to the ICCU, fuse and 12V battery failures. History includes 6 attached ICCU related Repairs. #1 ICCU updated under recall SC271 at 31,678 miles. #2 Then the ICCU was replaced under recall SC302 at 45,059 miles. #3 Then the ICCU was replaced along with fuse and 12V battery after on road failure and tow in at 52,296 miles. #4 Then the ICCU was updated under recall SC327. #5 Then the ICCU, fuse and 12V battery was replaced at 69,849 miles under recall SC327 after another on road failure and tow in. #6 Then there was a ICCU overheat and charging fault related to a bad ICCU coolant reservoir cap after a charging failure and tow in at 70,957 miles.
The contact owns a 2022 Kia EV6. The contact received notification of NHTSA Campaign Number: 24V867000 (Electrical System) and the vehicle was repaired at the local dealer. The contact stated that four months later while driving 75 MPH, there was a popping sound coming from the rear of the vehicle. The message to "Check Electrical System" was displayed, and the vehicle unexpectedly decelerated to approximately 45 MPH. The contact continued driving and the message to "Stop Vehicle and Check Power Supply" was displayed. The vehicle decelerated to 5 MPH and failed to accelerate as intended. The vehicle was pulled over to the side of the road and inspected. All the doors were unlocked, and the vehicle then stalled. The vehicle failed to restart. The vehicle was towed to a dealer where it was diagnosed and determined that the Integrated Charging Control Unit (ICCU) assembly and fuse needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 148,309.
The contact owns a 2022 Kia EV6. The contact received notification of NHTSA Campaign Number: 24V867000 (Electrical System) and the vehicle was repaired at the local dealer. The contact stated that four months later while driving 75 MPH, there was a popping sound coming from the rear of the vehicle. The message to "Check Electrical System" was displayed, and the vehicle unexpectedly decelerated to approximately 45 MPH. The contact continued driving and the message to "Stop Vehicle and Check Power Supply" was displayed. The vehicle decelerated to 5 MPH and failed to accelerate as intended. The vehicle was pulled over to the side of the road and inspected. All the doors were unlocked, and the vehicle then stalled. The vehicle failed to restart. The vehicle was towed to a dealer where it was diagnosed and determined that the Integrated Charging Control Unit (ICCU) assembly and fuse needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 148,309.
Iccu failure and defective drivers seat. Was covered under warranty but took over a year to finish all defective parts. Still not 100%
Iccu failure and defective drivers seat. Was covered under warranty but took over a year to finish all defective parts. Still not 100%
The car has 41,000 miles and has experienced the second failure of the ICCU, so it will have a third unit in 3 years. The noteworthy issue is the risk associated with these failures. The unit failed on the freeway, and power was reduced to 20% (estimate), which put me and others in danger. This is apparently a known and significant issue with KIA. As a consumer, I am extremely concerned it will experience a 3rd failure, which could include immediate risk to self and passengers. How is this acceptable? Thanks for providing the forum to discuss.
The car has 41,000 miles and has experienced the second failure of the ICCU, so it will have a third unit in 3 years. The noteworthy issue is the risk associated with these failures. The unit failed on the freeway, and power was reduced to 20% (estimate), which put me and others in danger. This is apparently a known and significant issue with KIA. As a consumer, I am extremely concerned it will experience a 3rd failure, which could include immediate risk to self and passengers. How is this acceptable? Thanks for providing the forum to discuss.
The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 64 MPH, the left side of the steering wheel seized, and the vehicle aggressively jerked to the left into oncoming traffic. The message “Smart Cruise Disabled” was displayed. The contact was able to quickly regain control of the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 65,300.
The contact owns a 2022 Kia EV6. The contact stated that while driving approximately 64 MPH, the left side of the steering wheel seized, and the vehicle aggressively jerked to the left into oncoming traffic. The message “Smart Cruise Disabled” was displayed. The contact was able to quickly regain control of the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 65,300.
The ICCU failed and had to be replaced. This is a known issue.
The ICCU failed and had to be replaced. This is a known issue.
The ICCU failed which was part of the recall. Kia is unwilling to honor repairs beyond the 100,000 mile warranty which is unacceptable because there is still no resolution and it is subject to potential future failure. I need an extended warranty.
The ICCU failed which was part of the recall. Kia is unwilling to honor repairs beyond the 100,000 mile warranty which is unacceptable because there is still no resolution and it is subject to potential future failure. I need an extended warranty.
Driving down highway and check electrical vehicle system came on vehicle said pull over as soon as safely possible EV six started to go into turtle mode slow down to half speed then quarter speed before I was able to pull it into a safe spot took it into dealer after having it to be towed ICCU failure and they are ordering a new part for replacement. Also drained the entire 12 V battery.
Driving down highway and check electrical vehicle system came on vehicle said pull over as soon as safely possible EV six started to go into turtle mode slow down to half speed then quarter speed before I was able to pull it into a safe spot took it into dealer after having it to be towed ICCU failure and they are ordering a new part for replacement. Also drained the entire 12 V battery.
My car was / is one of thousands of Kia cars based on the eGMP platform to experience an ICCU failure. This is believed to be a design issue. While the repair was covered, reports indicate that the problem is not solved and will re-occur in time.
My car was / is one of thousands of Kia cars based on the eGMP platform to experience an ICCU failure. This is believed to be a design issue. While the repair was covered, reports indicate that the problem is not solved and will re-occur in time.
I am reporting a recurring safety and reliability issue with my 2022 Kia EV6 GT-Line (VIN: [XXX] ). The vehicle currently has approximately 63,100 miles. The vehicle repeatedly displays a “Check Electric Vehicle System” warning message. This problem has occurred three separate times. On at least two occasions, the vehicle became undriveable and required towing. The failure appears to affect the vehicle’s electric powertrain or control systems. The vehicle is currently being taken again to the dealership (Lou Sobh Kia in Cumming, Georgia) for diagnosis of the same issue. This will be the third service visit for this recurring failure. Because this issue can cause the vehicle to become unexpectedly inoperable, I am concerned about the safety implications and believe it may indicate a broader defect affecting Kia EV6 vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I am reporting a recurring safety and reliability issue with my 2022 Kia EV6 GT-Line (VIN: [XXX] ). The vehicle currently has approximately 63,100 miles. The vehicle repeatedly displays a “Check Electric Vehicle System” warning message. This problem has occurred three separate times. On at least two occasions, the vehicle became undriveable and required towing. The failure appears to affect the vehicle’s electric powertrain or control systems. The vehicle is currently being taken again to the dealership (Lou Sobh Kia in Cumming, Georgia) for diagnosis of the same issue. This will be the third service visit for this recurring failure. Because this issue can cause the vehicle to become unexpectedly inoperable, I am concerned about the safety implications and believe it may indicate a broader defect affecting Kia EV6 vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The vehicle lost the ability to charge on Level 2 and Level 1 charging. I took it to the Kia dealer and they told me it was the ICCU, took then a week to repair.
The vehicle lost the ability to charge on Level 2 and Level 1 charging. I took it to the Kia dealer and they told me it was the ICCU, took then a week to repair.
ICCU issue. Car showed zero percent battery after charging all night. No warning lights no errors
ICCU issue. Car showed zero percent battery after charging all night. No warning lights no errors
Perhaps 1 year into owning this car the apple carplay connection started going in and out-- it takes perhaps 10 to 15 seconds for it to start working again. I've tried different phones and cords. This issue is getting worse, sometimes 6 times in a 20 minute drive. Now it goes out very frequently (though it is rare in the mornings for some reason). I have brought the car into a dealership and they cannot find any issue with the car. At the recommendation of the dealership I switched the cord to an official apple cord, but when I did this the connection would be lost and I'd have to reach down, disconnect the cord, and reconnect it to get the screen to come back on-- I have since switched back to an Anker cord. There have been many drivers with the same EV6 reporting this issue in Kia FB groups. Now that the car is about 4 years old, it happens very frequently (one time 6 times in a 10 minute span). The safety issue comes in as one, some people may be reaching to disconnect and reconnect their cord while driving, which can be a distraction and may lead to increase in accidents, two, if someone is on a call they may disconnect the cord and switch to speaker, which again is a distraction, and three, I have also been using the navigation system through the carplay, and when the map goes out my turn is going up it can cause me to hesitate on whether to turn or not (and perhaps if the screen comes on at the last minute, make a quick turn, which can increase risk of collision).
Perhaps 1 year into owning this car the apple carplay connection started going in and out-- it takes perhaps 10 to 15 seconds for it to start working again. I've tried different phones and cords. This issue is getting worse, sometimes 6 times in a 20 minute drive. Now it goes out very frequently (though it is rare in the mornings for some reason). I have brought the car into a dealership and they cannot find any issue with the car. At the recommendation of the dealership I switched the cord to an official apple cord, but when I did this the connection would be lost and I'd have to reach down, disconnect the cord, and reconnect it to get the screen to come back on-- I have since switched back to an Anker cord. There have been many drivers with the same EV6 reporting this issue in Kia FB groups. Now that the car is about 4 years old, it happens very frequently (one time 6 times in a 10 minute span). The safety issue comes in as one, some people may be reaching to disconnect and reconnect their cord while driving, which can be a distraction and may lead to increase in accidents, two, if someone is on a call they may disconnect the cord and switch to speaker, which again is a distraction, and three, I have also been using the navigation system through the carplay, and when the map goes out my turn is going up it can cause me to hesitate on whether to turn or not (and perhaps if the screen comes on at the last minute, make a quick turn, which can increase risk of collision).
A warning came up on the dashboard to “Check electric vehicle system”. 12v battery light also on. Vehicle went into limp mode and drove at 45 mph max for a period of time, then dropped to 27 mph max. Inspections at Ziegler Kia in Holland, MI, found the ICCU was faulty and needs to be replaced. This vehicle has already had the ICCU recall applied, yet ICCU has failed again.
A warning came up on the dashboard to “Check electric vehicle system”. 12v battery light also on. Vehicle went into limp mode and drove at 45 mph max for a period of time, then dropped to 27 mph max. Inspections at Ziegler Kia in Holland, MI, found the ICCU was faulty and needs to be replaced. This vehicle has already had the ICCU recall applied, yet ICCU has failed again.
I was unable to charge this electric vehicle which I normally do almost once or twice a week using my home level 2 charger. It also did not speak the message that "your vehicle is being charged" which it normally does when I charge the vehicle. I tried multiple times. Then I got into the vehicle and saw that it was giving me the following error messages (pics included below) upon trying to start it. 1. "Check Electric Vehicle System" 2. "Battery Discharge Warning - Please use the vehicle after starting the vehicle". However the vehicle would not start and then it went went totally dead. Kia was kind enough to tow it under warranty to Century Kia in Tampa, FL as well as now they are trying to identify the issue. Kia was also kind enough to provide me a rental via Century Kia which I appreciate.
I was unable to charge this electric vehicle which I normally do almost once or twice a week using my home level 2 charger. It also did not speak the message that "your vehicle is being charged" which it normally does when I charge the vehicle. I tried multiple times. Then I got into the vehicle and saw that it was giving me the following error messages (pics included below) upon trying to start it. 1. "Check Electric Vehicle System" 2. "Battery Discharge Warning - Please use the vehicle after starting the vehicle". However the vehicle would not start and then it went went totally dead. Kia was kind enough to tow it under warranty to Century Kia in Tampa, FL as well as now they are trying to identify the issue. Kia was also kind enough to provide me a rental via Century Kia which I appreciate.
The iccu failed on this car rendering the whole vehicle useless. This part is currently a recall and I was using a new ICCU with the software update per their recall solution. My second ICCU failed at approximately 40k miles.
The iccu failed on this car rendering the whole vehicle useless. This part is currently a recall and I was using a new ICCU with the software update per their recall solution. My second ICCU failed at approximately 40k miles.
When attempting to level one charge the vehicle at home, the car returned a failure to charge error and would not charge. This was attempted several times using different outlets and the same error occurred. The car was brought to Gettel Kia in Bradenton Florida. The dealership confirmed that the ICCU had failed,. They did not have the part and apparently it is on backorder. The repair is being covered under warranty, however, it is not being considered a recall, despite many other Kia EV6s having ICCU failures. The ICCU failures are extensive and need to be further investigated by NHSTA and a full recall for all Kia EV6s should be ordered.
When attempting to level one charge the vehicle at home, the car returned a failure to charge error and would not charge. This was attempted several times using different outlets and the same error occurred. The car was brought to Gettel Kia in Bradenton Florida. The dealership confirmed that the ICCU had failed,. They did not have the part and apparently it is on backorder. The repair is being covered under warranty, however, it is not being considered a recall, despite many other Kia EV6s having ICCU failures. The ICCU failures are extensive and need to be further investigated by NHSTA and a full recall for all Kia EV6s should be ordered.
While driving the vehicle a short distance, I heard a loud pop from the back seat. The car immediately warned of an electrical system failure. The issue and symptoms are consistent with ICCU module failures, reported across the kia/hyundai egmp platform. My safety was put risk, because I was stopped in heavy traffic when this happened and could have been stranded far from home with no ability to drive the vehicle more than a couple of miles at most. The warnings started immediately after the pop I heard.
While driving the vehicle a short distance, I heard a loud pop from the back seat. The car immediately warned of an electrical system failure. The issue and symptoms are consistent with ICCU module failures, reported across the kia/hyundai egmp platform. My safety was put risk, because I was stopped in heavy traffic when this happened and could have been stranded far from home with no ability to drive the vehicle more than a couple of miles at most. The warnings started immediately after the pop I heard.
my 2022 ev6 iccu went bad at 106,000 miles. I took it to the dealer at 99,000 for iccu safety recall. the dealership did not replace the iccu at the safety recall. the dealer wants me to pay 4000 dolllars to fix it....they should have replace it at the safety recall. kia goose creek, south carolina
my 2022 ev6 iccu went bad at 106,000 miles. I took it to the dealer at 99,000 for iccu safety recall. the dealership did not replace the iccu at the safety recall. the dealer wants me to pay 4000 dolllars to fix it....they should have replace it at the safety recall. kia goose creek, south carolina
ICCU unit lost power and the car was unable to drive. Luckily I was parked when it happened but if I had been driving it would have been very dangerous. The part was replaced under warranty but they said it could happen again which really scares me.
ICCU unit lost power and the car was unable to drive. Luckily I was parked when it happened but if I had been driving it would have been very dangerous. The part was replaced under warranty but they said it could happen again which really scares me.
Persistent ICCU failure causing charging interruptions, “Check Vehicle Charging System” → “Stop vehicle and check power supply” warnings, low 12V battery voltage (down to 12.1V), and risk of power loss/strand. Kia Connect sent “Charge Interrupted” alert during a session that reached 99%. Multiple prior recalls/attempts failed to resolve (Sep 2023 TSB ELE291 BMS, Jun 2024 SC271 ICCU SW, Jan 2025 SC273 VCU SW, May 2025 SA5999 limp-home logic, Sep 2025 dead 12V stranding). Towed Feb 2026 after stranding; dealer confirmed ICCU failed (DTC P1A9096), replaced ICCU (P/N 36400-1XFA0AQQK latest revision), fuse, and SW update under SC327 (24V-867). Repair completed same day (Feb 24, 2026), but dealer skipped charging system test and filling coolant. Safety impact: Stranded wife twice (dead battery and iccu failure), tow required, potential sudden power loss while driving. Report purpose: Document recurrence despite multiple recalls; seeking NHTSA tracking for effectiveness of SC327 remedy.
Persistent ICCU failure causing charging interruptions, “Check Vehicle Charging System” → “Stop vehicle and check power supply” warnings, low 12V battery voltage (down to 12.1V), and risk of power loss/strand. Kia Connect sent “Charge Interrupted” alert during a session that reached 99%. Multiple prior recalls/attempts failed to resolve (Sep 2023 TSB ELE291 BMS, Jun 2024 SC271 ICCU SW, Jan 2025 SC273 VCU SW, May 2025 SA5999 limp-home logic, Sep 2025 dead 12V stranding). Towed Feb 2026 after stranding; dealer confirmed ICCU failed (DTC P1A9096), replaced ICCU (P/N 36400-1XFA0AQQK latest revision), fuse, and SW update under SC327 (24V-867). Repair completed same day (Feb 24, 2026), but dealer skipped charging system test and filling coolant. Safety impact: Stranded wife twice (dead battery and iccu failure), tow required, potential sudden power loss while driving. Report purpose: Document recurrence despite multiple recalls; seeking NHTSA tracking for effectiveness of SC327 remedy.
My car (Kia EV6) suddenly stopped charging with Level 1 and Level 2 charging. I brought it to the Kia dealership and it was diagnosed ICCU failure. ICCU was swapped and the car is charging again.
My car (Kia EV6) suddenly stopped charging with Level 1 and Level 2 charging. I brought it to the Kia dealership and it was diagnosed ICCU failure. ICCU was swapped and the car is charging again.
ICCU failure. The vehicle would no longer charge via AC and tripped the circuit breaker whenever plugged in. All necessary software updates related to the ICCU issue were completed timely before its failure.
ICCU failure. The vehicle would no longer charge via AC and tripped the circuit breaker whenever plugged in. All necessary software updates related to the ICCU issue were completed timely before its failure.
The contact owns a 2022 Kia EV6. While the contact’s daughter was driving approximately 40 MPH, the messages "Electric Failure: Stop Car Do Not Drive” and “12-Volt Battery Voltage Low" were displayed on the instrument panel. The vehicle then failed to exceed 20 MPH, causing the driver to activate the hazard lights while pulling over to a side street while driving approximately 5 MPH. On the side of the road, the vehicle lost power. The vehicle was left at the side of the road to be towed to the nearest dealer. The dealer was contacted and confirmed that it was a known failure with the Interior Command Centre Unit(ICCU), and that the ICCU might need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.
The contact owns a 2022 Kia EV6. While the contact’s daughter was driving approximately 40 MPH, the messages "Electric Failure: Stop Car Do Not Drive” and “12-Volt Battery Voltage Low" were displayed on the instrument panel. The vehicle then failed to exceed 20 MPH, causing the driver to activate the hazard lights while pulling over to a side street while driving approximately 5 MPH. On the side of the road, the vehicle lost power. The vehicle was left at the side of the road to be towed to the nearest dealer. The dealer was contacted and confirmed that it was a known failure with the Interior Command Centre Unit(ICCU), and that the ICCU might need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 23,000.
vehicle will not charge properly due to ICCU failure, causing it to not charge the 12v battery which could have caused it to run out of battery at any moment causing the car to stop operating while driving which could have caused an accident, particularly because I do mostly highway driving. The dealership has confirmed the ICCU failure. While it supposedly got the previous recall fixes, that did not prevent it from failing.
vehicle will not charge properly due to ICCU failure, causing it to not charge the 12v battery which could have caused it to run out of battery at any moment causing the car to stop operating while driving which could have caused an accident, particularly because I do mostly highway driving. The dealership has confirmed the ICCU failure. While it supposedly got the previous recall fixes, that did not prevent it from failing.
The ICCU system in my 2022 Kia EV6 failed for the SECOND time on the highway. The car threw an error telling me to "Check the electrical system" and "Pull over safely immediately" or something similar. Had I not made it to the shoulder, I would have been completely stranded in the middle of the highway, creating an incredibly dangerous situation. This is the second time this has happened with my EV6 in less than 50,000 miles on this car. I had to call a tow truck. I confirmed with the Kia dealership the ICCU system had randomly failed and was required to be replaced *AGAIN*. My wife was in the car with me and was freaked out. She doesn't feel safe in it because there's no rhyme or reason to when it happens. KIA says it is a known issue, and confirmed it was the second time this has happened to my car. No symptoms prior to it happening. We were just driving and then suddenly the car lost power and the warning displayed on the dash.
The ICCU system in my 2022 Kia EV6 failed for the SECOND time on the highway. The car threw an error telling me to "Check the electrical system" and "Pull over safely immediately" or something similar. Had I not made it to the shoulder, I would have been completely stranded in the middle of the highway, creating an incredibly dangerous situation. This is the second time this has happened with my EV6 in less than 50,000 miles on this car. I had to call a tow truck. I confirmed with the Kia dealership the ICCU system had randomly failed and was required to be replaced *AGAIN*. My wife was in the car with me and was freaked out. She doesn't feel safe in it because there's no rhyme or reason to when it happens. KIA says it is a known issue, and confirmed it was the second time this has happened to my car. No symptoms prior to it happening. We were just driving and then suddenly the car lost power and the warning displayed on the dash.
Incident occured october 17, 2024. Was driving approximately 30mph on a local road when lights flashed to "check electric vehicle system". Was speed restricted to 25mph (on 45mph road) and was able to make it back home approximately 1 mile away. Car completely shut down in my street prior to making it to my driveway. It needed to be towed to the nearest dealership. No lights in dash working and flickering. Prior to this failure over the preceding several months there were errors where I would plug the car into Level 2 charging at home (9.6kWh) and the car would stop charging with a hot charging port approximately every 1 hour. I would unplug and replug in again. Charging would work. Level 3 was working just fine without problem. After going to the dealership it was deemed that the ICCU component needed to be replaced. After replacing car worked well and no charging issues occured.
Incident occured october 17, 2024. Was driving approximately 30mph on a local road when lights flashed to "check electric vehicle system". Was speed restricted to 25mph (on 45mph road) and was able to make it back home approximately 1 mile away. Car completely shut down in my street prior to making it to my driveway. It needed to be towed to the nearest dealership. No lights in dash working and flickering. Prior to this failure over the preceding several months there were errors where I would plug the car into Level 2 charging at home (9.6kWh) and the car would stop charging with a hot charging port approximately every 1 hour. I would unplug and replug in again. Charging would work. Level 3 was working just fine without problem. After going to the dealership it was deemed that the ICCU component needed to be replaced. After replacing car worked well and no charging issues occured.
While driving in traffic I heard a pop, then the "Check Electric Vehicle System" warning came on the dashboard. After a minute or so the dash warning changed to "Stop Vehicle" and the car limped home but at a lower speed. This matched the description I had seen of ICCU failures on Kia and Hyundai EVs. Dealer confirmed this was in fact the issue, and I had it replaced under warranty. This was a safety issue for me and my family because when it failed I was driving in traffic on a four-lane road at night, in <40-degree weather, and it requires a tow to the dealership for repair. Although I now have a new ICCU, I am also now concerned that it might happen again. The vehicle has not been inspected by police, insurance or manufacturer that I'm aware of.
While driving in traffic I heard a pop, then the "Check Electric Vehicle System" warning came on the dashboard. After a minute or so the dash warning changed to "Stop Vehicle" and the car limped home but at a lower speed. This matched the description I had seen of ICCU failures on Kia and Hyundai EVs. Dealer confirmed this was in fact the issue, and I had it replaced under warranty. This was a safety issue for me and my family because when it failed I was driving in traffic on a four-lane road at night, in <40-degree weather, and it requires a tow to the dealership for repair. Although I now have a new ICCU, I am also now concerned that it might happen again. The vehicle has not been inspected by police, insurance or manufacturer that I'm aware of.
While driving at speed, I heard a pop noise from the car. A few seconds later, I received notification to check vehicle electric system. The vehicle slowed down despite my increasing throttle input. I was able to limp to a parking lot where it was flat bed towed. This experience matches a previous issue I had when it was diagnosed with an ICCU failure with the same vehicle.
While driving at speed, I heard a pop noise from the car. A few seconds later, I received notification to check vehicle electric system. The vehicle slowed down despite my increasing throttle input. I was able to limp to a parking lot where it was flat bed towed. This experience matches a previous issue I had when it was diagnosed with an ICCU failure with the same vehicle.
Showing top 50 of 259 complaints (sorted by severity, most recent first). Full records available via NHTSA ODI search.
What Owners Are Saying
"1\. This is even more fun to drive than expected - just terrific. I'm not talking torque, but overall road feel and sense of high quality build. 173KSdrmiami replied Apr 23, 2022 Kia EV6 Forum Ken7 Feb 27, 2022 Ride quality vs other EVs? I have a BMW i4 on order (ordered 7 months ago, getting really tired of the wait) and have a Lucid Air Pure reserved as a backup. I'm very interested in the EV6 too after seeing it a local dealer and taking a very brief test drive. I've watched countless YouTube videos as well as having read... 36.4Kvoxel replied Feb 28, 2022 Kia EV General Discussion Forum"
"186.8KDivus replied Jun 16, 2022 Kia EV6 Forum electriclove May 14, 2022 Comparing EV6 HDA2 w/ Tesla Autopilot I just got an EV6 and love it. I’ve been a Tesla guy for about 10 years, largely because they were the first real EV you could buy and remained the only real exciting option until just recently. We have 4 Teslas currently! (Tho will be selling 2 of them shortly) 1122KFrankMN replied May 15, 2022 Kia EV6 Forum dtonn Aug 22, 2022 Does Kia seem to be emphasizing RWD right now? In the Phoenix area I have seen only RWD models coming in for several weeks now. Is this widespread?"
"Real Winter Range 2022 Kia EV6. Snapshot of real winter range in the Midwest with snow tires and snow-mode on. Frankly still the best for in city driving and short commutes upto 50 miles one way without a problem."
"Just bought a 2023 Kia EV6 GT-line RWD (in Australia) - what to buy and what to know? Hi folks, I've just bought a 2023 GT-line RWD in white - got what I think is a pretty good deal, it's ex-dealer demo, only owned by Kia and their associated used car dealership, and only 121kms (that's total, not thousand) on the odometer for AUD$49,990. It's currently on the back of a truck headed to me in the next week or 2. I've been reading up on the car and community, and have a few questions if you'll indulge me: 1. I plan to charge at home. The dealership has included an EVSE Mini Portable Type 2 charger (8A, 6m, blue). I have solar but no battery (13.3kw, huge production and exports) and my daily commute is only a 24km round trip. Does it sound feasible to only charge the car with the portable charger, mainly on weekends and the occasional working from home day to take advantage of the solar, without installing a type 2 wallbox charger? (I also have DC fast chargers located 3 minutes from my house - they're expensive but could be used in a pinch if I need to top up for a road trip). 2. I plan to buy a 7m type 2 to type 2 EVSE cable for destination charging. I know nothing about using Tesla's charging network, including what's open to non-Teslas and what's not, and whether I need any adaptors or cables. What's the easiest way to find out about this and get reliable information, without trawling plugshare? And am I likely to need any other cables or the like? 3. I live in Canberra. I sometimes road trip to Berry (217km) and back another day, or to Nelson Bay (488km) and back another day (sometimes with a stopover in Sydney). Coming from a diesel car with 1100km range so I know I'll need to change my habits somewhat. ABRP suggests that for the Berry trip I wouldn't need to charge until I get there, and for Nelson Bay I'd only need to stop once for about 10-20 minutes or so (depending on what SOC I'll accept when I get there). Both trips involve going up and down mountain passes or at least really big hilly ranges. Are these scenarios realistic? Has anyone done these trips and if so, is it common to wait for a charge? And how much is the range likely to reduce in winter? 4. In terms of accessories, so far I've bought some x-car 3D car mats and sunshades, and a back seat cover to keep it as pristine as I can (got 2 kids and a dog - the kids are constantly spilling or dropping food). I plan to get a jump-starter kit in case the 12v battery dies at any stage. Imight look at a dashcam, and at some stage possibly to swap out the centre console plastic from piano black to something else. Are there any other accessories people consider essential or real quality of life improvements that I should be thinking about? 5. The car has been sitting on a dealer lot for the past couple of years, and only being driven and charged occasionally. It will probably have been sitting idle for at least about a month by the time it gets to me. Do I need to be prepared for the po"
"2022 EV6 First Edition - An Owners 1-year Retrospective Spoiler: It's been an absolute shit show Here's a link to my first post on this sub: I took the advice of a commenter on that first post, and drafted an email to the Director of Consumer Affairs and Warranty Operations for Kia Motors America. Here's that email, which includes my experiences for roughly the first half of 2024: ***Good Afternoon,*** ***I hope this email finds you well. I am writing to express my deep dissatisfaction with the service and repairs performed on my 2022 EV6 First Edition at (redacted dealership #1). To wit:*** ***I bought my EV6 used with ±28k miles in January. The 12v battery died for the first time (foreshadowing) the day before I went into the aforementioned dealership to get new tires installed, so I called to add a diagnosis of the battery issue to my service appointment. Sat in the dealership for 4 hours, and my service advisor came out a few times to make statements ranging from "Your battery isn't under warranty" (it was less than 36 months old, for reference) to "Ok, actually it is", to "It tests fine, so it's not eligible for warranty replacement". I got the last update from the advisor 5 minutes after they closed, so I didn't even have the option to simply buy a new battery. The advisor suggested that my mistake was jumping my car and driving it in, and if I had it towed with a dead battery, it might have tested low enough for replacement. Good to know. My car was finally ready about 15 minutes later, and the advisor came out to ask if I would like a car wash. Given that they had been officially closed for almost half-an-hour at this point, and that I been there for the entire day, I said "no". "That's what I figured" the advisor replied. I hindsight, it's probably good I passed on the car wash, because when I got home, I inspected the wheels and noticed black smudges and scratches on all 4 wheels. The dealer damaged all 4 alloys on the wheel balancing machine in the process of installing the new tires.*** ***I went back in to the dealership after work 3 days later (unannounced) to mention this damage, the fact the battery had once again died earlier that day, and that the amount of vibration I was getting at highway speed sure made it seem like the wheels hadn't been balanced (in spite of the damage/evidence suggesting otherwise). Neither the service advisor or service manager had any clue how the damage could have happened, but said they would coordinate with the contractor they work with for rim repairs on getting the damage assessed and repaired. We agreed I would come in Saturday (this was Tuesday), but if I could be there earlier, I'd let them know. While I was in the shop, I paid out-of-pocket to have a new battery installed.*** ***Over the next few days, I tried 3 or 4"
"2022 KiaEV6 the good the bad and the ugly. Watch your wallet First I would like to start this review by saying I drove this car almost ever day for 5 months. It has 45,336 miles I bought it brand new with 140 miles on it. I drove for Uber I would charge it twice a day at a DC fast charger and once a day slow charge at night. I would like to say this is just my personal experience with this car driving it 12 to 16 hours a day. I will start with the good. Do I recommend? Yes and no. If you live near a city then you will probably only charge once a week at the most. It would cost me about $5.00 to $8.00 to charge from 20% to 90% this car is made for the city. It drives and rides nice. It looks sharp and turns heads. People loved this car. The bad The heat sucks and so does the defrost. Now the Ugly I started off when I got the car with 240-305 miles on a 90% charge. A 100% at 320 miles. A lot of 260+ miles. As time went on I would only get 240 miles with heat and everything off. Then I started to get about 228 miles. Then out of the clear blue in about a time frame of 3-4 weeks I started to get 218 then down to 206 miles. So I called a few Kia to get a price on a new battery.. they tell me that they cannot get a new battery because they are only making batteries for the manufacturing of new cars. They can only put my name on a waiting list. The cost is $29,000 😢 I feel that if you only live in a city and charge once a week you might be fine. Yes I did use this car a lot but I feel the battery should last longer then 50,000 miles Hope this helps someone looking into buying the all new Kia EV6 I sold it and went back to a gas 2023 Toyota Highlander xle"
"Consumer Reports drops its recommendation for Kia EV6 (2025) The new reports cites Predicted Reliability with the charging/electrical systems. >The EV6 is Kia’s first EV-only design. In our highway range test of our dual-motor EV6, we were able to travel 277 miles on a full charge. The Kia is taut and agile, and the ride is steady and comfortable. It glides silently down the road and accelerates briskly. Visibility to the sides and rear is restricted, and the car is saddled with annoying split-use climate and audio controls. >EV6 owners reported problems with the EV charging system, electrical accessories, paint/trim, climate system, and body hardware. >When asked for comment, a Kia spokesperson said, “Kia America is proud of our well-earned reputation for producing high-quality vehicles. >“While disappointed to learn of the loss of Consumer Reports’ recommendation of the EV6, Kia is committed to building reliable vehicles and has taken action to address the reported issues: >• Kia America issued Safety Recall Campaigns to inspect, and if necessary, replace the Integrated Charging Control Unit (ICCU) in affected 2022-2024 EV6/EV6 GT vehicles. • Safety Recall Campaigns related to the ICCU will be repaired at no cost to our customers. • Kia America supports our customers through our industry-leading 10-year/100,000-mile powertrain limited warranty. >“Kia customers are encouraged to contact Kia Consumer Affairs at 800-333-4542 with any questions or concerns related to these or any other Kia vehicle matters.” Photos & Video: 2025 Kia EV6 Photos & Video - Consumer Reports"
"My Kia EV6 (2021-2024) was stolen via “GameBoy” gadget — what can owners do? Hi everyone, I’m posting here because my EV6 (year 2022) was stolen recently, and the circumstances look like the more to GAMEBOY theft method that’s being reported widely for Kia/Hyundai group EVs. I’ve already contacted Kia Europe, my local dealer, and a well-known EV YouTuber, but I haven’t seen a meaningful response yet from Kia about any broad recall/patch or clear guidance. I wanted to raise awareness and see if any owners here know more about what Kia is doing (or plans to do) — and what we, as a community, are doing to protect ourselves. **Questions I’d like fellow owners to help answer:** 1. Has anyone here (EV6 owner) knows if Kia plans some *software or hardware security update/recall/notice* specifically for this vulnerability? 2. Do you know if the newer model(s) (EV3, EV4 or EV6 refresh) have improved security / different keyless entry protocol / better immobiliser / or have Kia explicitly said so? 3. What additional protection measures are you using and how effective do you feel they are? 4. Have you raised this with the dealer or Kia and did they respond with anything concrete?"
Showing 8 of 75 owner excerpts (sorted by sentiment strength)